Fantasma4500
International Hazard
Posts: 1677
Registered: 12-12-2012
Location: Dysrope (aka europe)
Member Is Offline
Mood: dangerously practical
|
|
Uses of NaClO?
hey so, im making sodium chromate by electrolyzing chromium hydroxide with NaCl present, and it can be done with H2O2 also, but its much less
effective. so i got to think.. what else can you create with in-situ formed ClO-? or Cl2?
sadly chloroform by electrolysis isnt doable, but using trichloroisocyanuric acid and NaOH does yield a lot of NaClO and can then be utilized like
that
what reactions can be done with H2O2 solely?
ammonium compounds are dangerous to make with electrolysis as you can end up with CCl3, any general rules for donts with organic compounds in
electrolysis?
|
|
|
mysteriusbhoice
Hazard to Others
Posts: 473
Registered: 27-1-2016
Member Is Offline
Mood: Became chemistry catboy Vtuber Nyaa
|
|
why wouldnt chloroform with electrolysis work??
you need to use CaCl2 not NaCl for that one bud because chloroform reaction with NaOCl will make NaOH which is soluble but Ca(OH)2 is not.
|
|
|
BauArf56
Hazard to Self
Posts: 68
Registered: 22-8-2019
Location: between the moon and the sun
Member Is Offline
Mood: energetic
|
|
but would electrolysis of a solution of calcium chloride give calcium hypochlorite?
|
|
|
mysteriusbhoice
Hazard to Others
Posts: 473
Registered: 27-1-2016
Member Is Offline
Mood: Became chemistry catboy Vtuber Nyaa
|
|
yea but then it reacts with the acetone to make chloroform or if not add sodium chloride to catalyze the reaction since that species is more likely.
either way you end up with Ca(OH)2 precipitating out in the brine.
|
|
|
Fantasma4500
International Hazard
Posts: 1677
Registered: 12-12-2012
Location: Dysrope (aka europe)
Member Is Offline
Mood: dangerously practical
|
|
you could end up with COCl2, phosgene, very poisonous. by adding acetone to an electrolysis cell
|
|
|
njl
National Hazard
Posts: 609
Registered: 26-11-2019
Location: under the sycamore tree
Member Is Offline
Mood: ambivalent
|
|
Aqueous phosgene...
Reflux condenser?? I barely know her!
|
|
|
mysteriusbhoice
Hazard to Others
Posts: 473
Registered: 27-1-2016
Member Is Offline
Mood: Became chemistry catboy Vtuber Nyaa
|
|
U have a source for this well its not unreasoable but id like to see a source for this.
The more likely byproduct would be chloroacetone from what I read in the past.
Phosgene would not occur during chlorine evolution and a porous split cell can also isolate the acetone from the anode chamber which will prevent any
direct oxidation.
IEM wouldnt work because it wont make NaClO but instead NaOH.
[Edited on 16-6-2021 by mysteriusbhoice]
|
|
|
Fantasma4500
International Hazard
Posts: 1677
Registered: 12-12-2012
Location: Dysrope (aka europe)
Member Is Offline
Mood: dangerously practical
|
|
im not quite sure that would work, if the NaClO can get out, the acetone should also be able to get in, i might be ignorant to the ionic "particle"
size of acetone vs NaClO however.
|
|
|
macckone
International Hazard
Posts: 2159
Registered: 1-3-2013
Location: Over a mile high
Member Is Offline
Mood: Electrical
|
|
Acetone and HCl yield chloroacetone products, if you take it far enough you get trichloroacetone.
Adding sodium hydroxide to trichloroacetone yields sodium acetate and chloroform.
There is a russian paper on it.
Russian Chemical Bulletin Volume 38 issue 2 1989 [doi 10.1007%2Fbf00953639] V. G. Malaev; V. A. Ilyushin -- Study of the electrochemical chlorination
of acetone
They produced trichloroacetone using a diaphram cell with sodium bicarbonate.
Here is a thread on electrolysis of acetone on sciencemadness:
http://www.sciencemadness.org/talk/viewthread.php?tid=936&am...
|
|
|
BromicAcid
International Hazard
Posts: 3227
Registered: 13-7-2003
Location: Wisconsin
Member Is Offline
Mood: Rock n' Roll
|
|
@njl Phosgene reacts shockingly slow with water, not speaking to if you'd make phosgene with this rxn but aqueous phosgene is a thing.
|
|
|
Fantasma4500
International Hazard
Posts: 1677
Registered: 12-12-2012
Location: Dysrope (aka europe)
Member Is Offline
Mood: dangerously practical
|
|
dichloroacetic acid can be used to make nitromethane iirc, reacted with NaNO2
trichloroacetic acid can be reacted with NaOH to make chloroform, destructive distillation
TCAA is also very sellable online, they charge lots of money as its used for skin peeling
from the paper
Conclusions
1.
The electrochemical chlorination of acetone in aqueous hydrochloric acid leads to a mixture of mono- and dichloro derivatives, the ratio of which is a
function of the current passed.
2.
The electrochemical chlorination of monochloroacetone and 1,1-dichloroacetone in carbonate buffer solution leads to 1,1,1-trichloroacetone in good
yield.
so first up HCl + acetone electrolysis, current decides ratio of mono/di
then monochloroacetone and dichloroacetone in carbonate to make trichloroacetone
i would kinda say, as diabolic as chloroacetone is to handle it kinda slips out of DIY
at least it put the phosgene acetone electrolysis thing in the grave, very nice.
|
|
|
![[*]](images/xpblue/default_icon.gif){kind=icon}
