Sciencemadness Discussion Board
Not logged in [Login ]
Search the forums Search   Frequently Asked Questions FAQ   View member list Member List   Today's Posts Today's Posts   Forum Stats Stats Back to: sciencemadness.org
Sciencemadness Discussion Board » Engineering and Equipment » Reagents and Apparatus Acquisition » Ammonium Nitrate Synthesis - NH4NO3 Go To Bottom

Printable Version  
Author: Subject: Ammonium Nitrate Synthesis - NH4NO3
AlphaDecay
Hazard to Self
**



Posts: 60
Registered: 20-3-2014
Location: Uranium-238
Member Is Offline

Mood: Emitting Helium-4

[*] posted on 20-3-2014 at 11:09
Ammonium Nitrate Synthesis - NH4NO3

I have been searching everywhere on the internet about this reaction:
2KNO3 + [NH4]2SO4 -> K2SO4 + 2NH4NO3

Since potassium sulfate is less soluble (111g/L - 20 degrees celsius) than potassium nitrate (316g/L - 20 degrees celsius), could this metathesis reaction happen?
View user's profile View All Posts By User
Zyklon-A
International Hazard
*****



Posts: 1547
Registered: 26-11-2013
Member Is Offline

Mood: Fluorine radical

[*] posted on 20-3-2014 at 11:24


Yes,but I would suggest dissolving your potassium nitrate in the minimal amount of hot water. Then pour that into the stoichiometric amount of ammonium sulfate in equally hot water, to drive the equilibrium completely to the right.
The solubility of [NH4]2SO4 in hot water doesn't change too much: 241 g/L, vs. KNO3: 1410g/L at 100°C.



[Edited on 20-3-2014 by Zyklonb]



View user's profile View All Posts By User
Dr.Bob
International Hazard
*****



Posts: 2659
Registered: 26-1-2011
Location: USA - NC
Member Is Offline

Mood: No Mood

[*] posted on 20-3-2014 at 12:17


And NH4NO3 is quite soluble, so if you filter off the first crop of K2SO4, then you may be able to let it sit a few days and evaporate a bit and then filter off (or decant away the liquid) yet more K2SO4 to continue the reaction further to the right.

From "The purification of lab chemicals" book:

"NH4NO3 can be recrystallized from distilled water (1 g/ml) by adding EtOH or from warm water (1g/0.5 ml) by cooling with an ice/salt bath."

[Edited on 20-3-2014 by Dr.Bob]
View user's profile View All Posts By User
*FWOOSH*
Hazard to Self
**



Posts: 90
Registered: 6-9-2013
Location: ooo esss ahhh
Member Is Offline

Mood: manic

[*] posted on 20-3-2014 at 14:47


I was doing something similar with calcium nitrate and ammonium sulphate, both cheap as hell and I think calcium sulphate is going to be a lot easier to remove.
View user's profile View All Posts By User
Zyklon-A
International Hazard
*****



Posts: 1547
Registered: 26-11-2013
Member Is Offline

Mood: Fluorine radical

[*] posted on 20-3-2014 at 14:54


Yep, calcium sulfate will be much easier to seperate as it will immediately precipitate.



View user's profile View All Posts By User
AlphaDecay
Hazard to Self
**



Posts: 60
Registered: 20-3-2014
Location: Uranium-238
Member Is Offline

Mood: Emitting Helium-4

[*] posted on 20-3-2014 at 15:27


Ok, thanks for your help.
View user's profile View All Posts By User

 Sciencemadness Discussion Board » Engineering and Equipment » Reagents and Apparatus Acquisition » Ammonium Nitrate Synthesis - NH4NO3   Go To Top